Vermont-casting DVR33 Manual de usuario

1Vermont Castings, Majestic Products: DVR3310004920Homeowner's Installation andOperating ManualINSTALLER: DO NOT DISCARD THIS MANUAL - LEAVE FO

10Vermont Castings, Majestic Products: DVR3310004920Canadian Installations1US Installations2A = Clearance above grade, veranda, porch,12 in. (30 cm)

11Vermont Castings, Majestic Products: DVR3310004920General Information for Connecting Vent PipesCrimped End PipesBefore joining elbows and pipes, ap

12Vermont Castings, Majestic Products: DVR3310004920Max. 20"(508 mm)Top view flat installationMax. 20"(508 mm)Top view corner installation

13Vermont Castings, Majestic Products: DVR3310004920(240mm)9³⁄₈"10³⁄₈"(254mm) 7¹⁄₂"(190mm)Vent Opening — Combustible WallVent Opening

14Vermont Castings, Majestic Products: DVR3310004920Since it is very important that the venting systemmaintain its balance between the combustion air

15Vermont Castings, Majestic Products: DVR3310004920 “A”10’(3048 mm)7’6”(2286 mm)90° Elbow = 3’V584-201A + B = 17’ (5.2 m) max.Fig. 22 Maximum vent

16Vermont Castings, Majestic Products: DVR3310004920Vertical Sidewall Installation#8 Screws (2)#8 Screws (2)12" (304.8 mm)max.Firestop(Side View

17Vermont Castings, Majestic Products: DVR3310004920Fig. 27 Horizontal length requirement.Below Grade InstallationCFM193Fig. 28 Below grade install

18Vermont Castings, Majestic Products: DVR3310004920WatertightSeal Around PipeFoundationRecessSheetmetal screwsWall screwsSnorkelCFM139Fig. 29 Snork

19Vermont Castings, Majestic Products: DVR331000492011"11"Attic InsulationShieldUpper FloorCeilingInstallationJoistNails (4)FirestopSpacerF

2Vermont Castings, Majestic Products: DVR3310004920Table of ContentsThank You and Congratulations on Your Purchase of a Vermont Castings, Majestic Pr

20Vermont Castings, Majestic Products: DVR3310004920 DVR33 Bracket Restricter InstallationFig. 35 Baffle firebox assemblyNOTES: When installing DVR3

21Vermont Castings, Majestic Products: DVR3310004920Twist Lock Venting Components7DVRVT - Through-the-Wall Rear Vent TerminationStarter Kit-Model 7TD

22Vermont Castings, Majestic Products: DVR33100049207DVRVT - Through the wall Rear Vent TerminationStarter Kit-Model 7DVSK - Sidewall VentingStarter

23Vermont Castings, Majestic Products: DVR3310004920Operating InstructionsUse only glass approved by VermontCastings, Majestic Products on thisfirepl

24Vermont Castings, Majestic Products: DVR3310004920RN/RP and EN/EP ModelsFor units equipped with ‘HI/LO’ valves the flameadjustment is accomplished

25Vermont Castings, Majestic Products: DVR3310004920This appliance venting system is designed andconstructed to develop a positive flow adequate tore

26Vermont Castings, Majestic Products: DVR33100049203. Open louvre assembly bottom.4. Push in gas control knob slightly and turnclockwise to "

27Vermont Castings, Majestic Products: DVR3310004920Lighting and Operating InstructionsFor Fireplaces equipped with SIT822 Gas Valve (EN or EP)A. Thi

28Vermont Castings, Majestic Products: DVR3310004920Troubleshooting – Honeywell Millivolt ValveSTART CHECKGas Supply ON▼▼▼▼▼Pilot lights with Piezoig

29Vermont Castings, Majestic Products: DVR3310004920WARNING: BEFORE DOING ANY GAS CONTROL SERVICE WORK, REMOVE GLASS FRONT.SYMPTOM POSSIBLE CAUSES C

3Vermont Castings, Majestic Products: DVR3310004920This gas appliance should be installed by a qualified installerin accordance with local building c

30Vermont Castings, Majestic Products: DVR3310004920SIT 822 Valve with a Honeywell Electronic IgniterNOTE: Remove glass before servicing.START TURN

31Vermont Castings, Majestic Products: DVR3310004920Fuel Conversion InstructionsHoneywell Gas Control Valve (Fig. 48):The Honeywell valve fitted to t

32Vermont Castings, Majestic Products: DVR3310004920Regulator CapConversion ScrewPressureRegulatorHousingHoneywell Gas ValveCO123Fig. 48 Honeywell g

33Vermont Castings, Majestic Products: DVR33100049204920 DVR33 parts Vermont Castings, Majestic Products reserves the right to make changes in design

34Vermont Castings, Majestic Products: DVR33100049204041423919302928272524Vermont Castings, Majestic Products reserves the right to make changes in d

35Vermont Castings, Majestic Products: DVR33100049203a. Pilot Assembly SIT Top Convertible RN 100022643b. Pilot Assembly SIT Top Convertible RP 10002

36Vermont Castings, Majestic Products: DVR3310004920DVR33 (continued) (Items marked ‘*’ are not shown in the parts illustration.)Ref. Description DVR

37Vermont Castings, Majestic Products: DVR3310004920Optional AccessoriesFK-24 Fan AssemblyFan specifications: 120 volt, 60 Hz, 0.75 Amp.This fan does

38Vermont Castings, Majestic Products: DVR3310004920Do not remove the existing windowframe assembly.SidepanelFloor refractory panelLog SupportLowersi

39Vermont Castings, Majestic Products: DVR3310004920Decorative Frame TrimsA selection of decorative frame trim kits are availablefor mounting around

4Vermont Castings, Majestic Products: DVR3310004920Appliance DimensionsFireplace DimensionsA 33” 838 mmB287/8” 733 mmC163/8” 416 mmD 31” 787 mmE221/1

BASIC WARRANTYThe Vermont Castings, Majestic Products Company (hereinafterreferred to collectively as the Company) warrants that your newVermont Casti

5Vermont Castings, Majestic Products: DVR3310004920MantelsThe height that a combustible mantel is fitted abovethe fireplace is dependent on the depth

6Vermont Castings, Majestic Products: DVR3310004920Fig. 5 Adjustable drywall strip (nailing flanges).CABAdjustable Drywall Strip(Nailing Flange)Scre

7Vermont Castings, Majestic Products: DVR3310004920The gas pipeline can be brought in through the side ofthe fireplace as well as the bottom. Knocko

8Vermont Castings, Majestic Products: DVR3310004920FP580Fig. 9 EB-1 receptacle.5. Connect black wire of the power supply line to thebrass screw (pol

9Vermont Castings, Majestic Products: DVR3310004920Fig. 10 Honeywell Ignition Module.This appliance may be fitted with a HoneywellIgnition Module.T